Call us on: 01202 717191

CAME FrogPlus - 230v Underground Double Swing Gate Kit

Product Volt Weight
max
per leaf
Angle
max
per leaf
Width
max
per leaf
Type Price Buy
CAME FrogPlus P5 Kit
230v
700kg
95°
5.5m
Underground
£6,111.13+vat

£7,333.36 inc.vat
CAME FrogPlus P7
230v
550kg
95°
7m
Underground
£6,111.13+vat

£7,333.36 inc.vat

Kit Contents

2 x Motor
2 x Foundation Box
1 x Frequency Card
2 x Wired Safety Photocells
1 x Control Board
2 x Radio Remote
1 x Antenna
2 x Release Mechanism
1 x Instruction Manual
1 x RGSM Connectivity Kit

Products bought with CAME FrogPlus - 230v Underground Double Swing Gate Kit

 

Frog Plus is the new underground solution for swing gates up to 7m per leaf. Typically found in commercial or industrial settings (army bases, prisons, hospitals etc.) Frog-Plus is unmatched in terms of power and can even move large swing hangar doors.

To see an introductory video of the Frog Plus then click here.

 

Frog Plus is fitted with the new generation ZM3EP control panel, specifically engineered to ensure the system's top management performance, even for very large gates. In fact, besides the normal command and safety functions, the new ZM3EP electronics state-of-the-art functionalities and special details which provide total control of the operator and optimal service levels.

 

  • Self-diagnosing safety devices.
  • Function programming and viewing display.
  • Gate-run control and encoder-based obstacle detection. If someone or something comes into contact with the gate while it's in motion, it will stop and back off.
  • Stores radio commands with different codes (up to 250 users).
  • Safety is ensured even when the gate is still. Each command is cancelled if any obstacles are detected by the safety devices.

 

 

Withstands anything!

The materials used and the high IP67 protection-rating from weather agents, make Frog Plus extremely resistant over time while cutting back on periodic maintenance.

 

Foundation box

Built of very thick steel and treated with cataphoresis rust-proofing.

 

Cutting-edge electronics

Guarantees all evolved functionalities for automation control and user safety.

 

A green light for frequent passages

Frog Plus is ideal for contexts with high traffic flow-rates.

 

 

 

All underground motors will operate underwater when new, but if left submerged, it is likely that water will eventually enter the motor and / or cable insulation will become porous. It is better to correctly drain the foundation cases from day one to protect your investment! Some additional fabrication/welding may be necessary to connect the drive shoe to your gates.

 

Remember if fitting underground drivers to wooden gates, it will be necessary to clad the gate bottom edge with metal to spread the load and to give something to attach the motor shoe. If you don't, the push-pull from the high torque will eventually split the wood.

 

 

Kit Contents

2 x Motor
2 x Foundation Box
1 x Frequency Card
2 x Wired Safety Photocells
1 x Control Board
2 x Radio Remote
1 x Antenna
2 x Release Mechanism
1 x Instruction Manual
1 x RGSM Connectivity Kit
Proteco Price Match Promise Order before 3pm Why buy from us? Gate Safe

Gate Automation

Please select what type of automation you require for your gate/s. Double & Single Swing refer to motors which attach to the gate and pillar of a swing motion gate. Double & Single Underground refer to motors which lay beneath the ground which attach to the hinge end of swing motion gates. Choose Sliding if you require lateral moving gate automation and Wheeled if you require a motor which utilises a wheeled motor to drive your gate/s.

Motor Voltage

There are two types of power outputs to consider - 24v & 230v. If you need a higher number of operations (opened/closed more than 5-6 times in an hour) during peak periods such as the morning and evening, then you may wish to consider a 24v system.

24v systems are more suitable for higher operation levels as they tend to run cooler than 230v gate motors. However, they do cost more in relative terms, so if you only need to open or close the gate 1-5 times an hour then a 230v system might prove more cost-efficient.

24v motors tend to be used on commercial premises, whereas 230v tend to be used on standard domestic properties. The exception to this rule is sliding gate motors where the reverse is true - 24v sliding gate automation systems tend to be for domestic use, 230v for more intense use (commercial/communal).

24v systems can draw power from battery backup systems meaning they can still operate during any mains power cut (a 230v or 3 phase system would need to be opened with a manual release key).

24v systems can also utilise solar power units as a means of charging batteries, allowing you to site gate automation in rural and remote locations where mains power is unavailable.

Specifications can be found for each product from their datasheet. Each datasheet is downloadable from each product page on this website.

Weight of Gate

All electric gate motors operate up to a maximum weight. This is so the gate will operate in a reliable and safe manner. It is essential to know the weight of each gate leaf in order to choose the correct motor for you installation. If you do not know the weight of your gate/s, send us a photo along with the gate/s dimensions and we can advise.

Gate Width

As with weight, gate motors are designed for gates within certain dimensions. The most important dimension is the width of the gate. To ensure you select the right motor to operate your gate you must know the width of each gate that requires automation.

Opening Angle

Each motor has a maximum angle to which it can operate to. Therefore it is important to note how far the gate needs to open in order for a vehicle to enter/exit safely.

Daily Use

The amount of times your gate is used per day is a determining factor when deciding on the right motor for your usage. Motors are designed to operate within a certain capacity (operations per day) so choosing a motor compatible with your desired use is essential for its durability. Select from the options below the number of times (open & closure = 1 x operation) the gate/s will be operated on an average day.